电伴热配件您当前的位置:首页 > 服务产品 > 电伴热配件 > 详细信息

BJW51-120防爆温度控制器

信息来源:皖缆集团 浏览次数:6365 发布时间:2014-03-10

防爆温度控制器按照GB3836-2000《爆炸性环境用防爆电气设备》的有关规定制造,防爆标志“EⅡBT4”,产品分陆用和船用两类,适用于二区爆炸性气体混合物T1-T4温度级别场合自动控制管线或罐体的介质工艺温度。
芯盒里装有控温元件。控温元件调节轴和测温毛细管采用隔爆结构和胶封结构,供控制电缆的进线和出线使用。
  

BJW51-120防爆温度控制器

 

一、工作原理
温控器感温包接触到的被控介质温度升高时,温包中的液体受热膨胀,当被控介质超过设定温度时,T1、T2触点断开,于是自动切断电源,停止伴热。此时,感温包温度慢慢降低;当温度低于设定温度时,触点T1、T2重新闭合,又自动回复送电。


二、技术参数
型号BJW51-120
防爆合格证号:CNEx14.0252U
额定电流:15A
额定电压:~220V
防爆标志:ExdllCT4
环境温度:-40℃~+200℃
调温范围:10-120
防护等级:IP54


三、安装维护
(1)打开温控器接线盒盖,拧下接套,将进、出线电缆各自穿过接套、压圈、橡胶密封圈进入接线腔。
(2)在工作电压为220V/110V的单项系统中,将进、出线中各自一根芯线分别装在“T1”和“T2”接线柱上,剩下的一根进线和一根出线接在“短接”线柱上,然后拧紧线盖螺钉。
(3)在380V三相系统中,必须增加一只交流接触器KM,将其主接触点接入负载回路,温控器的触点T1、T2接入220V或380V的控制回路,通过KM线圈得电、失电来控制负荷回路的通与断。安装时,来自配电箱的一根二芯控制电缆通过一只线嘴进入接线腔,接在温控器T1、T2触点上,另一只线嘴空着不用。
(4)打开温度调节盖,将旋钮上的介质工艺温度数对准芯壳上的红色上基准点,然后上紧盒盖螺钉。
(5)将盒座用管卡固定在管道的适当部位(一般在电源接线盒附件),并将测温毛细管用耐热压敏胶带敷设在被测管管表面,感温包用铝箔胶带紧贴在管道被测温度的部位上,并用耐热压敏胶带扎牢。测温毛细管安装部位应远离电伴热带,以防误动作。
(6)电源线接入电网,控制线通过防爆电源接线盒接入电伴热带,检查无误后即可送电工作。
(7)温控器安装注意事项
a、感温包只能水平安装、盒垂直向下安装,否则会出现温度不稳定现象。
b、接线盒如有变形、裂痕盒损坏,应停止使用,更换新的温控器
(8)温控元件是否正常工作的判断方法
将万用表电阻档接触“T1”、“T2”触点:从低到高转动调温旋转,在气温刻度线附件(温包放在空气中)能听到“卟卟”触点开闭响声,且万用表指针由“断→通”,则表示正常;若指针不动,表示温控元件已坏。

 

电伴热带温控器多视图

 

相关信息:防爆温度控制器安装使用与维护说明书

 

快三平台开奖直播
  • http://www.hn1c.com/howuU/65390920.html
  • http://www.hn1c.com/howuU/28297.html
  • http://www.hn1c.com/howuU/3272974.html
  • http://www.hn1c.com/howuU/16857390.html
  • http://www.hn1c.com/howuU/9608598.html
  • http://www.hn1c.com/howuU/9348424.html
  • http://www.hn1c.com/howuU/71528.html
  • http://www.hn1c.com/howuU/43823572.html
  • http://www.hn1c.com/howuU/0039993.html
  • http://www.hn1c.com/howuU/61627533.html
  • http://www.hn1c.com/howuU/2747.html
  • http://www.hn1c.com/howuU/7756.html
  • http://www.hn1c.com/howuU/731515.html
  • http://www.hn1c.com/howuU/589593.html
  • http://www.hn1c.com/howuU/3914813.html
  • http://www.hn1c.com/howuU/82300.html
  • http://www.hn1c.com/howuU/4544282.html
  • http://www.hn1c.com/howuU/790292.html
  • http://www.hn1c.com/howuU/04837196.html
  • http://www.hn1c.com/howuU/50012794.html
  • http://www.hn1c.com/howuU/3789338.html
  • http://www.hn1c.com/howuU/3871754.html
  • http://www.hn1c.com/howuU/860890.html
  • http://www.hn1c.com/howuU/9367538.html
  • http://www.hn1c.com/howuU/8915.html
  • http://www.hn1c.com/howuU/998364.html
  • http://www.hn1c.com/howuU/36622767.html
  • http://www.hn1c.com/howuU/3599.html
  • http://www.hn1c.com/howuU/823680.html
  • http://www.hn1c.com/howuU/79822.html
  • http://www.hn1c.com/howuU/712773.html
  • http://www.hn1c.com/howuU/7796174.html
  • http://www.hn1c.com/howuU/786716.html
  • http://www.hn1c.com/howuU/7103088.html
  • http://www.hn1c.com/howuU/22813902.html
  • http://www.hn1c.com/howuU/0663.html
  • http://www.hn1c.com/howuU/06163305.html
  • http://www.hn1c.com/howuU/98895.html
  • http://www.hn1c.com/howuU/2282575.html
  • http://www.hn1c.com/howuU/5141720.html
  • http://www.hn1c.com/howuU/851229.html
  • http://www.hn1c.com/howuU/37026848.html
  • http://www.hn1c.com/howuU/8074.html
  • http://www.hn1c.com/howuU/16796.html
  • http://www.hn1c.com/howuU/06253.html
  • http://www.hn1c.com/howuU/91057.html
  • http://www.hn1c.com/howuU/5091.html
  • http://www.hn1c.com/howuU/45299.html
  • http://www.hn1c.com/howuU/15869750.html
  • http://www.hn1c.com/howuU/25490.html
  • http://www.hn1c.com/howuU/80316.html
  • http://www.hn1c.com/howuU/70235.html
  • http://www.hn1c.com/howuU/06328.html
  • http://www.hn1c.com/howuU/96827745.html
  • http://www.hn1c.com/howuU/43947.html
  • http://www.hn1c.com/howuU/8274.html
  • http://www.hn1c.com/howuU/3858.html
  • http://www.hn1c.com/howuU/56773614.html
  • http://www.hn1c.com/howuU/5512.html
  • http://www.hn1c.com/howuU/6592.html
  • http://www.hn1c.com/howuU/188322.html
  • http://www.hn1c.com/howuU/1904.html
  • http://www.hn1c.com/howuU/7206063.html
  • http://www.hn1c.com/howuU/54498.html
  • http://www.hn1c.com/howuU/6992894.html
  • http://www.hn1c.com/howuU/1471834.html
  • http://www.hn1c.com/howuU/49427129.html
  • http://www.hn1c.com/howuU/28054084.html
  • http://www.hn1c.com/howuU/3074.html
  • http://www.hn1c.com/howuU/06753.html
  • http://www.hn1c.com/howuU/6785.html
  • http://www.hn1c.com/howuU/957837.html
  • http://www.hn1c.com/howuU/4409.html
  • http://www.hn1c.com/howuU/60789016.html
  • http://www.hn1c.com/howuU/3183529.html
  • http://www.hn1c.com/howuU/9171659.html
  • http://www.hn1c.com/howuU/0001825.html
  • http://www.hn1c.com/howuU/6812.html
  • http://www.hn1c.com/howuU/863854.html
  • http://www.hn1c.com/akaAQ/35631613.html
  • http://www.hn1c.com/akaAQ/850499.html
  • http://www.hn1c.com/akaAQ/3316935.html
  • http://www.hn1c.com/akaAQ/573318.html
  • http://www.hn1c.com/akaAQ/3128759.html
  • http://www.hn1c.com/akaAQ/3804.html
  • http://www.hn1c.com/akaAQ/8074.html
  • http://www.hn1c.com/akaAQ/0778487.html
  • http://www.hn1c.com/akaAQ/45851829.html
  • http://www.hn1c.com/akaAQ/1214156.html
  • http://www.hn1c.com/akaAQ/92696.html
  • http://www.hn1c.com/akaAQ/09293.html
  • http://www.hn1c.com/akaAQ/69185212.html
  • http://www.hn1c.com/akaAQ/764352.html
  • http://www.hn1c.com/akaAQ/395643.html
  • http://www.hn1c.com/akaAQ/9464.html
  • http://www.hn1c.com/akaAQ/45215643.html
  • http://www.hn1c.com/akaAQ/61795291.html
  • http://www.hn1c.com/akaAQ/82865.html
  • http://www.hn1c.com/akaAQ/7341.html
  • http://www.hn1c.com/akaAQ/125908.html